Services / Service One
BMW INSPECTION I
Undercarriage:
-
Change engine oil and oil filter while engine is at operating temperature
-
Check transmission for leaks.
-
Check rear axle for leaks.
-
Half shafts: Check for leaks at flexible boots.
-
Visually check fuel tank, lines and connections for leaks.
-
Check condition, position, and mounting of exhaust system. Examine for leaks.
-
Check power steering system for leaks. Check P/S fluid level; add fluid necessary.
-
Check overall thickness of front and rear disc brake pads. If replacement is necessary: Examine brake disc surfaces. Clean brake pad contact points in calipers. Grease wheel centering hubs. Check thickness of parking brake linings only when replacing rear pads.
-
Check brake (and clutch) system connections and lines for leaks, damage, and incorrect positioning.
-
Check steering for absence of play, condition of suspension track rods, front axle joints, steering linkage and joint disc.
-
Check parking brake actuation. Adjust if necessary.
-
Check all tire pressures (including spare). Correct if necessary. Check condition of tires (outer surfaces [left/right]), tread wear and pattern; in case of uneven tread wear readjust wheel alignment if requested. Note : If requested, rotate all four road wheels as instructed and rebalance.
- Inspect entire body according to terms of rust perforation limited warranty (must be performed at least every two years).
Engine Compartment:
-
Read out diagnostic system.
-
Check engine cooling system / heather hose connections for leaks. Check coolant level and antifreeze protection level; add coolant if necessary. Note : Coolant must be replaced every 4 years (time interval begins from vehicle's production date).
-
Check level of brake and clutch fluid in reservoir. Add fluid if required.
-
Replace brake fluid every 2 years (time interval begins from vehicle's production date).
-
Check windshield washer fluid level and antifreeze protection. Fill up and/or correct if necessary.
-
Check air conditioner for operation.
-
Replace micro filters. Note : Reduce replacement interval in dusty operating conditions.
- Reset Service Indicator.
Body/Electrical Equipment:
-
Check battery state-of-charge, and charge if required.
-
Check lighting system, i.e., headlights, foglights, parking, back-up, license plate, interior (including map reading lights), glove box, flashlight, illuminated make-up mirrors, luggage compartment lights.
-
Check instrument panel and dashboard illumination.
-
Check all warning/indicator lights, check control.
-
Check turn signals, hazard warning flashers, brake lights, horns, headlight dimmer/flasher switch.
-
Check wipers and washer system(S); wiper blades, washer jet positions.
-
Check condition and function of safety belts.
-
Check central locking/double lock.
-
Check operation of all latches.
-
Check heater/air conditioner blower fan, rear window defogger.
-
Check rear view mirrors.
-
Visually examine the SRS airbag units for torn covers, obvious damage or attachment of decals, decorations or accessories.
- Activate automatic roll-over protection system (if equipped) vis diagnostic link. Note: First remove hardtop/lower top.
Final Inspection:
- Road test with check of brakes, suspension, steering, clutch/manual transmission or automatic transmission.
